Material Safety Data Sheet Drathon Industrial Maintenance: Section 1 - Chemical Product and Company Identification [PDF]

Citation preview

MATERIAL SAFETY DATA SHEET DRATHON INDUSTRIAL MAINTENANCE SECTION 1 – CHEMICAL PRODUCT AND COMPANY IDENTIFICATION Company Name Emergency Telephone No Address Trade Name



PT Hermon Pancakarsa Libratama +62 24 7601234 Puri Anjasmoro H5 / 7 Semarang 50144 – INDONESIA Drathon 56.24



SECTION II – HAZARDS IDENTIFICATION Special Hazard for Man and Environment



SECTION III – COMPOSITION/INFORMATION ON INGREDIENTS COMPONENT (S) CHEMICAL NAME BASE Resin Pigment Additive Solvent HARDENER Hardener



PERCENTAGE 63% 25.5% 0.5% 11% 100%



SECTION IV – FIRST AID MEASURE In eyes - flush with large amount of water, get medical attention On skin - thoroughly wash exposed area with soap and water Ingestion - call Physician



SECTION V – FIRE FIGHTING MEASURES FLASH POINT (Method Used) FLAMMABLE LIMITS 81°F N.A. EXTINGUISHING MEDIA Foam, CO2, dry chemical SPECIAL FIRE FIGHTING PROCEDURES Wear full protective equipment, self contained breathing apparatus



Drathon 56.24



Page 1 of 3



UNUSUAL FIRE AND EXPLOSION HAZARDS Wear self-contained breathing apparatus . Closed containers may explode when exposed to extreme heat. Isolate from heat, electrical equipment, sparks & open flame. Vapors may spread long distances, cause flash fire or ignite explosively.



SECTION VI – ACCIDENTAL RELEASE MEASURES Avoid breathing of vapors. Use absorbent cleanup materials. Place in separate container. Keep out of sewers and waterways. If entry is threatened or occurs, notify local authorities. Eliminate all sources of ignition.



SECTION VII – HANDLING AND STORAGE Store in cool dry place. Store below 50°C in closed containers. Keep from freezing. Keep out of reach of children. Read entire label before using.



SECTION VIII – EXPOSURE CONTROLS, PERSONAL PROTECTION RESPIRATORY PROTECTION Use air-line respirators in confined of restricted ventilation area. VENTILATION Sufficient ventilation, in volume and pattern, should be provided to keep air contaminent concentrations below TLV limit. PROTECTION GLOVES Neoprene or non-soluble plastics EYE PROTECTION Splash -proof goggles or face shield OTHER PROTECTIVE CLOTHING OR EQUIPMENT Full protective clothing, spark-proof equipment. WORK/ HYGIENIC PRACTICES N.A



SECTION IX – PHYSICAL AND CHEMICAL PROPERTIES APPEARANCE & ODOR Liquid, solvent BOILING POINT 244 - 327°F VAPOR DENSITY Heavier than air SOLUBILITY IN WATER No



Drathon 56.24



SPECIFIC GRAVITY 1.1 MELTING POINT N.A. EVAPORATION RATE N.A. VAPOR PRESSURE (psig) -



Page 2 of 3



SECTION X – STABILITY AND REACTIVITY STABILITY



CONDITIONS TO AVOID Stable Heat , Open Flame INCOMPATIBILITY (Materials to Avoid) Strong Oxidizers, acids, alkalies, Epoxies under uncontrolled conditions HAZARDOUS DECOMPOSITION PRODUCTS CO and CO2, Coal Tar Fumes HAZARDOUS POLYMERIZATION Will Not Occur



SECTION XI – TOXICOLOGICAL INFORMATION May cause eye irritation, Excessive inhalation can cause headache, nausea or dizziness. Skin irritation accentuated by sunlight.



SECTION XII – ECOLOGICAL INFORMATION No data available



SECTION XIII – DISPOSAL CONSIDERATIONS In separate, closed metal container in accordance with all applicable regulations.



SECTION XIV – TRANSPORT INFORMATION No data available SECTION XV – REGULATORY INFORMATION R36/37/38: Irritating to eyes, respiratory system and skin



SECTION XVI – OTHER INFORMATION NFPA Rating Health H=1 Fire F=1 Reactivity R=1 Key : Blue = health; red = fire; yellow = reactivity; white = special hazard 0= minimal; 1=slight; 2=moderate; 3=serious; 4=severe We believe the statements, technical information and recommendations contained herein are reliable , but they are given without warranty or guarantee of any kind, express or implied, and we assume no responsibility for any loss, damage, or expense, direct or consequential, arising out of their use Last updated : December 19, 2012 Drathon 56.24



Page 3 of 3