![Manual de Parte Bulldozer d8t Volumne 3 [PDF]](https://pdfs.asia/img/200x200/manual-de-parte-bulldozer-d8t-volumne-3.jpg)
6 0 7 MB
SEBP-4154-03
INSTALLATION AND PARTS MANUAL MODEL PA140VS FOR CATERPILLAR D8T & D9T TRACTORS
TABLE OF CONTENTS Mounting Group . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-3 Control Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-5 Joystick Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . .6 Motor Lines Group . . . . . . . . . . . . . . . . . . . . . . . . . . . .7 Lines Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8-10 Manifold Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . .11 Valve Mounting Group . . . . . . . . . . . . . . . . . . . . .12-13 Motor Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14-15 Brake Valve Assembly . . . . . . . . . . . . . . . . . . . . . . . .16
Winch Housing Assembly . . . . . . . . . . . . . . . . . . .18-19 Brake Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20 Overrunning Clutch Assembly . . . . . . . . . . . . . . . . . .21 Carrier Clutch Assembly . . . . . . . . . . . . . . . . . . . . . .22 Input Shaft Detail . . . . . . . . . . . . . . . . . . . . . . . . . . . .23 Ring Gear Assembly . . . . . . . . . . . . . . . . . . . . . . . . .24 Secondary Planet Carrier Assembly . . . . . . . . . . . . .25 Output Planet Carrier Assembly . . . . . . . . . . . . . . . .26
PACR WINCH DIVISION LIT2280 R3 5/2009 PRINTED IN U.S.A.
P.O. BOX 547 BROKEN ARROW, OK U.S.A. 74013 PHONE (918) 251-8511 FAX (918) 259-1575
www.paccarwinch.com
MODEL PA140A MOUNTING GROUP D8T
ITEM NO
PART NO
DESCRIPTION
QTY
20
7X-0427
21
152-8372
BRACKET, LH
CAPSCREW, HEX HD (1¼ - 7 X 3½, G8, Z)
10 1
22
152-8371
BRACKET, RH
1
23
197-7837
HITCH PIN
1
24
3B-5320
COTTER PIN
2
25
7X-0533
WASHER, HARD (1¼ Z)
26
7X-2580
CAPSCREW, METRIC HEX HD (M30 X 3.5 X 90 mm, G10.9, Z)
14
27
9X-8258
WASHER, HARD (M30, Z)
14
10
2
MODEL PA140A MOUNTING GROUP D8T
THIS PAGE INTENTIONALLY LEFT BLANK
3
MODEL PA140A CONTROL GROUP D8T
NOTE: ITEM 2 (CONTROL DECAL) NOT SHOWN. INSTALL WHERE CLEARLY VISIBLE BY OPERATOR.
ITEM NO
PART NO
DESCRIPTION
QTY
1
209-2608
CONTROL, JOYSTICK ASSY (REFER TO PAGE 6)
1
2
235-7152
DECAL, WINCH CONTROL
1
3
222-7888
SWITCH
1
4
246-4311
SWITCH GUARD
1
4
PA140VS / D8T FULL POWER WINCH CONTROL W/DEDICATED DIRECTIONAL CONTROL VALVE
IMPLEMENT PUMP DISP: 129 cc/rev FLOW = 226 L/min AT 1850 RATED ENGINE RPM 270 L/min AT 2200 HI ENGINE RPM EFFICIENCY: 95% SPEED RATIO - PUMP: ENGINE 1:1 CUT OFF = 24000±350 kPa MARGIN = 2100±100 kPa
MODEL PA140A D8T
5
MODEL PA140A JOYSTICK ASSEMBLY D8T
1 NOTE
BUTTON ORIENTATION
IN RELATION TO MOUNTING PLATE
3
4
2
ITEM NO
PART NO
DESCRIPTION
1
235-5801
PLATE, MOUNTING
QTY
2
260-1982
HARNESS AS
1
3
269-9388
JOYSTICK, CONTROL
1
4
127-2170
CAPSCREW, BUTTON HD M8X1.25X20, G10.9
4
1
6
MODEL PA140A MOTOR LINES GROUP D8T
DETAIL C NOT TO SCALE
DETAIL A NOT TO SCALE
VIEW B-B NOT TO SCALE
VIEW D-D NOT TO SCALE
ITEM NO
PART NO
DESCRIPTION
QTY
1
1P-5766
SPLIT FLG, HALF
2
7X-0313
CAPSCREW, HEX HD (7/16-14 X 2-¾, G8, Z)
4
3
8T-5360
WASHER, HARD (7/16, Z)
4
2
4
1P-3703
D-RING
3
5
240-8865
HOSE -16 XT-5 X 32 in. (813 mm)
1
6
148-8317
ADAPTER
1
7
240-8862
HOSE -16 XT-5 X 34.5 in. (876 mm)
1
9
8W-6688
HOSE -4 X 26 in. (660 mm)
1
10
152-8360
HOSE ASSY -6 X 36 in. (914 mm)
1
11
148-8378
ELBOW, 90°
1
12
163-3189
HOSE -8 X 29 in. (737 mm)
1
13
148-8364
ELBOW, 90°
1
14
7X-0326
CAPSCREW, HEX HD (½-13 X 3, G8, Z)
1
15
1F-1560
SPACER
1
16
6D-7573
CLIP, DOUBLE
1
17
1S-6420
HOSE CLAMP
1
18
8T-4223
WASHER, HARD (½, Z)
2
19
148-8369
ELBOW, 90°
1
7
MODEL PA140A LINES GROUP D8T
Fuel Tank
Manifold from Lines GP-Pump
Fuel Tank Implement Valve
Bracket As. from Lines GP-Pump
Case
8
36 28
SECTION B-B
SECTION A-A
35
Connect Hose to Port Marked “W”
9 36 28
Implement Valve
35
VIEW E-E
Case
Bracket from Tank GP-Fuel
Bracket from Lines GP-Pump
FUEL TANK
SECTION D-D
SECTION C-C
MODEL PA140A LINES GROUP D8T
MODEL PA140A LINES GROUP D8T
ITEM NO
PART NO
DESCRIPTION
QTY
1
6V-0852
DUST CAP
1
2
146-7578
HOSE ASSY -8 X 43 in. (1092 mm)
1
3
150-4027
TEE
1
4
191-1443
MANIFOLD ASSY (REFER TO PAGE 11)
1
5
213-5003
HOSE ASSY -6 X 44 in. (1118 mm)
1
6
219-8051
WIRING HARNESS
1
7
238-5096
HOSE ASSY -16 X 40 in. (1016 mm)
1
8
238-5097
HOSE ASSY -16 X 37 in. (940 mm)
1
9
239-3327
BRACKET
1
10
148-8326
ADAPTER
1
11
148-8340
ADAPTER
1
12
148-8354
ELBOW, 45°
1
13
148-8407
PLUG
1
14
148-8411
PLUG
1
15
155-3624
PLUG
1
17
6V-0400
SPLIT FLG, HALF
4
18
1S-0994
HOSE CLAMP
2
19
3J-1907
O-RING
1
20
4J-0520
O-RING
4
22
5P-4295
HOSE CLAMP
1
23
6V-3965
ADAPTER, QD
1
24
7G-5984
CLIP HALF
1
25
7G-5985
CLIP HALF
1
26
7G-5986
GROMMET
1
27
8C-3206
FLANGE-HALF
28
8T-4121
WASHER, HARD (M10, Z)
29
8T-4136
CAPSCREW, HEX HD (M10 X 1.5 X 25, GR10.9, Z)
2
30
8T-4139
CAPSCREW, HEX HD (M12 X 1.75 X 30, GR10.9, Z)
2
31
8T-4184
CAPSCREW, HEX HD (M12 X 1.75 X 45, GR10.9, Z)
8
32
8T-4192
CAPSCREW, HEX HD (M12 X 1.75 X 25, GR10.9, Z)
2
33
8T-4195
CAPSCREW, HEX HD (M10 X 1.5 X 30, GR10.9, Z)
4
34
8T-4223
WASHER, HARD (½, Z)
35
1P-3703
SEAL
2
36
8T-4196
CAPSCREW, HEX HD (M10 X 1.5 X 35, GR10.9, Z)
8
4 14
12
10
MODEL PA140A MANIFOLD ASSEMBLY D8T
ITEM NO
PART NO
DESCRIPTION
QTY
1
220-1341
MANIFOLD & VALVE (INCLUDES ITEM 14, QTY 2)
1
2
161-8891
BRACKET
1
3
8T-4223
WASHER, HARD (½, Z)
2
4
8T-4139
CAPSCREW, HEX HD (M12 X 1.75 X 30mm, G10.9, Z)
2
5
4P-7581
CLIP
2
6
6V-8212
CAPSCREW, HEX HD (M10 X 1.5 X 16mm, G10.9, Z)
2
7
8T-4121
WASHER, HARD (M10, Z)
2
8
3E-3364
RECEPTACLE
1
9
3E-3365
WEDGE, CONNECTOR
1
10
3E-3370
RECEPTACLE, 3-PIN
1
11
3E-3371
WEDGE, CONNECTOR, 3-PIN
1
12
8T-8729
CONTACT PIN
4
13 14 15 16
8T-8737 126-0858 127-1955 126-3900
PLUG, CONNECTOR CARTRIDGE, SOLENOID VALVE (COMPLETE) SEAL KIT (FOR ITEM 14) COIL (FOR ITEM 14)
1 2 1 1
11
MODEL PA140A VALVE MOUNTING GROUP D8T
Pilot Supply On/Off Solenoid Valve 2-Pin Green & Blue
Filter Switch 2 Pin Blue & Black
Orange Purple
Blue Purple
Pink Gray
Purple White Pink Gray Purple Purple
SECTION B-B
ITEM NO 1 2 3 4 5
PART NO 210-7776 228-3105 228-3106 8T-4171 9X-8256
DESCRIPTION VALVE GROUP, CAT D8T (REFER TO PAGE 13) BRACKET BRACKET CAPSCREW, HEX HD (M6 X 1.00 X 12mm, G10.9, Z) WASHER, HARD (M6, Z)
12
QTY 1 1 1 8 8
MODEL PA140A VALVE MOUNTING GROUP D8T
Pilot Supply On/Off Solenoid Valve 2-Pin Green & Blue
Filter Switch 2 Pin Blue & Black
Orange Purple
Blue Purple
Pink Gray
Purple White Pink Gray Purple Purple
SECTION B-B
ITEM NO
PART NO
1
4T-1073
3
213-4326
4
4J-0522
5 6 7 8
DESCRIPTION
QTY
STUD
3
VALVE, DIRECTIONAL STACK EH
1
SEAL
3
4J-8997
O-RING
1
6V-5555
O-RING
3
8C-3206
FLANGE-HALF
2
8T-4196
CAPSCREW, HEX HD (M10 X 1.5 X 35, GR10.9, Z)
8
9
8T-4121
WASHER, HARD (M10, Z)
8
10
4J-0520
SEAL
2
NOTE: For spare parts information on 213-4326 Valve (Item 3), refer to the D8T Tractor Parts Book.
12
MODEL PA140A MOTOR GROUP D8T
14
MODEL PA140A MOTOR GROUP D8T
ITEM NO
PART NO
DESCRIPTION
QTY
531
158-6534
HYD MOTOR (3.34 CU IN, 3100 PSI)
532
8T-9398
CAPSCREW, HEX HD (¾-10 X 1¾, G8, Z)
2
533
8T-4994
WASHER, HARD (¾, Z)
2
534
3J-4567
CAPSCREW, HEX SKT HD ( /16-14 X 3 in., G8)
535
240-8858
BRAKE VALVE ASSY (REFER TO PAGE 16)
1
536
4F-7391
O-RING
3
537
126-0848
MOTOR COVER
1
538
5P-2566
CAPSCREW, HEX HD (½-13 X 1½, G8, Z)
11
539
8T-4223
WASHER, HARD (½)
11
7
1
4
540
119-1586
O-RING
1
541
126-0824
ADAPTER BLOCK
1
544
7U-8897
ADAPTER, METRIC
1
546 547
6V-9830 148-8432
CAP TEE
1 1
548
148-8369
ELBOW, 90°
1
549 550
150-4042 152-8368
ADAPTER HOSE -4 X 14 in. (356 mm)
1 1
551 553 554
152-8369 150-3033 6V-9828
HOSE -4 X 20 in. (508 mm) ELBOW, 45° CAP
1 1 1
555
126-0837 242-7225 240-8860 148-8378 6V-8627 197-8745 150-5968 196-0719 148-8353 242-1531 150-4037 242-0709 5P-2675 6V-8185 8T-4205
SPACER VALVE CARTRIDGE SEAL KIT (FOR 105330) ELBOW, 90° ELBOW, 90° HOSE -4 X 17 in. (432 mm) TEE HOSE -6 X 18.5 in (470 mm) ELBOW, 45° HOSE -6 X 27 in. (689 mm) TEE BRACKET CAPSCREW, HEX HD (¼-20 X 1¾, G8, Z) NUT, HEX (¼-20, Z) WASHER, HARD (¼, Z)
1 1 1 2 1 1 1 1 1 1 1 1 2 2 2
560 561 562 563 564 565 566 567 568 569 570 571 572 NOTE:
ITEMS NO's 537, 538 AND 539 SHOWN ON PAGE 18.
15
MODEL PA140A BRAKE VALVE ASSEMBLY D8T
ITEM NO.
PART NO.
-
240-8858
1
NSS
2 3
DESCRIPTION
QTY.
BRAKE VALVE AS.
1
BRAKE VALVE HOUSING
1
242-7228
VALVE SPRING RETAINER
1
242-7229
SPRING RETAINER
1
4
9S-8008
PLUG
1
5
NSS
SPOOL
1
6
NSS
7
7M-8485
SPOOL STOP
1
O-RING
1
8
NSS
CHECK VALVE POPPET
1
9
126-2453
PILOT ORIFICE
1
10
126-0817
CHECK VALVE SPRING
1
11
242-7227
SPRING, MAIN SPOOL
1
12
3D-2824
O-RING
2
13
4J-5268
O-RING
1
15
126-3349
BACK-UP RING
1
19
155-3624
PLUG
22
8J-7269
1
SHIM, SPOOL SPRING
AR
NSS - NOT SERVICE SEPARATELY AR - AS REQUIRED
16
THIS PAGE INTENTIONALLY LEFT BLANK
17
107
106
105
104
118
103
214
104
215
119
213
212
211
210
207
208
207
102
202
209 204
203
112
103
206
18 105
104
900
118
122
106
113
107
116
300
115 114
400
117 205
500
118 119
800
118 119
700
121
612
605
603
605
612
120
108
119
613
608
604
613
609
126
116
607
612
609
608
605 606
101
123
538 539
125
127
537
MODEL PA140A WINCH HOUSING ASSEMBLY D8T
MODEL PA140A WINCH HOUSING ASSEMBLY D8T ITEM # 101 102 103 104 105 106 107 108 112 113 114 115 116 117 118 119 120 121 122 123 125 126 127 201 203 204 210 211 212 213 214 215 300 400 500 537 538 539 540 600 700 800 900
PART # DESCRIPTION 126-2470 WINCH HOUSING CABLE DRUM (PACCAR P/N 107272) 110-8366 BEARING CONE 110-8368 BEARING CUP 126-0774 SPACER RING 5P-9171 RETAINING RING 126-0772 OIL SEAL 231-2226 RING GEAR ASSEMBLY (REFER TO PAGE 24) 148-8407 PLUG 126-0778 PLUG, MAGNETIC DRAIN 126-3230 PLUG, FILL 6U-1989 VENT PLUG 1K-6705 CAPSCREW, 1/2-13 UNC X 1/2 HEX HD, GD8 4H-6730 O-RING 5P-2566 CAPSCREW, 1/2-13 UNC X 1-1/2 HEX HD, GD8 8T-4223 WASHER, HARD FLAT, 1/2 126-0853 HOSE GUARD 8T-8917 CAPSCREW, 1/2-13 UNC X 1-1/4 HEX HD, GD8 5P-1076 WASHER, HARD FLAT, 1/2 152-8360 HOSE ASSEMBLY, -6 X 36 in (914 mm) 6V-9807 ELBOW, 90° 148-8353 ELBOW, 45° 6V-9829 CAP 231-2270 RING GEAR ASSEMBLY (REFER TO PAGE 23) 231-4084 THRUST WASHER 231-4088 NEEDLE ROLLER BEARING 231-2288 CARRIER CLUTCH ASSEMBLY (316:1 RATIO) (REFER TO PAGE 22) 231-4087 THRUST WASHER 231-4085 NEEDLE ROLLER BEARING 231-4089 THRUST WASHER 231-2247 COVER 1T-0132 O-RING 231-2224 BRAKE ASSEMBLY (REFER TO PAGE 20) 231-2225 OVERRUNNING CLUTCH ASSEMBLY -HYDRAULIC MOTOR GROUP (REFER TO PAGE 15) 126-0848 MOTOR COVER 8T-8917 CAPSCREW (1/2-13 UNC X 1-1/4 HEX HD GD8) 8T-4223 WASHER 1/2 HARDENED 119-1586 O-RING 140-7267 FAIRLEAD PARTS GROUP (SEE BELOW) 231-2262 OUTPUT PLANET CARRIER ASSEMBLY (REFER TO PAGE 26) 231-2229 SECONDARY PLANET CARRIER ASSEMBLY REFER TO PAGE 25) -RING GEAR ASSEMBLY (REFER TO PAGE 24)
QTY 1 1 4 4 2 2 2 1 1 1 1 1 2 1 54 54 1 2 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 11 11 1 1 1 1 1
FAIRLEAD ASSEMBLY ITEM #
PART #
603 604 605 606 607 608 609 612 613 -
126-0836 126-0835 126-0794 126-0834 228-0767 4L-6454 8T-4896 126-0806 3B-8489 171-7267
QTY 3 ROLLER 4 ROLLER VERTICAL ROLLER 2 2 VERTICAL SHAFT ASSEMBLY 2 2 BUSHING 6 8 HORIZONTAL ROLLER 1 2 HORIZONTAL SHAFT ASSEMBLY 1 2 CAPSCREW, 3/8-16 UNC X 1 in. HEX HD, GD8 3 4 WASHER, HARD, 3/8 3 4 WASHER - ROLLER 6 8 GREASE FITTING 6 8 FOURTH ROLLER KIT (INCLUDES ITEMS 605 - 613 TO ADD SECOND HORIZONTAL ROLLER) DESCRIPTION
19
MODEL PA140A BRAKE ASSEMBLY D8T
ITEM NO. 301 302 303 304 305 306 307 308 309 310 311 312 313 314 315 316 NOTE 1:
PART NO. 231-2224 231-2248 3Y-9267 096-5971 5L-5746 231-2250 231-2251 231-2252 231-2253 8J-1688 126-3170 8T-6444 231-4091 126-0798 231-2254 231-2256 231-4092
DESCRIPTION BRAKE ASSEMBLY BRAKE HOUSING (SEE NOTE 1) STEEL BALL (SEE NOTE 1) PLUG (SEE NOTE 1) RETAINING RING BRAKE PLATE SPACER BRAKE DISC FRICTION DISC BRAKE PISTON O-RING BACK-UP RING O-RING BACK-UP RING SPRING SPRING SPACER SPRING RETAINER RETAINING RING
IF REQUESTING ITEM 301, BRAKE HOUSING ITEMS 302 AND 303 MUST BE REQUESTED ALSO.
20
QTY. 1 1 1 1 1 2 9 8 1 1 1 1 1 16 1 1 1
MODEL PA140A OVERRUNNING CLUTCH ASSEMBLY D8T
THIS END TOWARD MOTOR SHAFT
INNER RACE TO ROTATE FREELY IN CLOCK-WISE (CW) DIRECTION WHEN VIEWED FROM THIS END.
405 404
402
403
401 406 404 405
ITEM NO.
PART NO.
DESCRIPTION
-
231-2225
OVERRUNNING CLUTCH ASSEMBLY
1
401
NSS
INNER RACE
-
402
NSS
OUTER RACE
-
403
NSS
OVERRUNNING CLUTCH
-
404
292-2320
BALL BEARING
2
405 406
292-2321 1L-3768
RETAINING RING RETAINING RING
2 1
NSS - NOT SERVICED SEPARATELY
21
QTY.
MODEL PA140A CARRIER CLUTCH ASSEMBLY D8T
ITEM NO. 1 2 3 4 5 6 7 8 9 10 11
PART NO. 231-2288 231-2289 231-2292 129-7306 129-7286 129-7307 126-0822 161-6434 161-6435 231-2245 231-2246 119-1534
DESCRIPTION CARRIER CLUTCH ASSEMBLY - 316:1 RATIO CARRIER CLUTCH - 316:1 RATIO PLANET GEAR - 316:1 RATIO PLANET GEAR SHAFT ROLLER BEARING BEARING RACE SPIROL PIN BRAKE PLATE FRICTION DISC WAVE SPRING THRUST RING RETAINING RING
22
QTY 1 1 3 3 3 6 3 7 6 5 1 1
MODEL PA140A INPUT SHAFT DETAIL D8T
900
ITEM # 900 202 205 206 207 208 209
PART # 231-2270 231-2889 231-2239 231-2240 064-0011 8H-9585 231-2281
DESCRIPTION RING GEAR ASSEMBLY (REFER TO PAGE 24) SPRING RETAINER INPUT SHAFT SECONDARY SUN GEAR THRUST RACE BEARING PRIMARY SUN GEAR 345:1 RATIO
23
QTY 1 1 1 1 4 2 1
MODEL PA140A RING GEAR ASSEMBLY D8T
904 902 903 905 906 907
901
PART #
DESCRIPTION
QTY
ITEM # -
231-2270
RING GEAR ASSEMBLY
901
231-2274
RING GEAR HOUSING
1
902
231-2237
CLUTCH PISTON
1
903
4M-0661
O-RING
1
1
904
1M-9015
O-RING
1
905
126-0780
SPRING
16
906 907
231-2238 PRESSURE PLATE 231-4083 RETAINING RING
1 2
24
MODEL PA140A SECONDARY PLANET CARRIER ASSEMBLY D8T
805 802
804 801
806 808
807
803
ITEM #
PART #
DESCRIPTION
QTY.
-
231-2229
SECONDARY PLANET CARRIER ASSEMBLY
1
801
1H-1200
SPIROL PIN
3
802
231-2230
PLANET PIN
3
803
231-2231
PLANET GEAR
3
804
126-0785
ROLLER
42
805
231-4080
THRUST WASHER
6
806
231-2232
SECONDARY PLANET CARRIER
1
807 808
231-2233 SUN GEAR 231-4082 RETAINING RING
1 1
25
MODEL PA140A OUTPUT PLANET CARRIER ASSEMBLY D8T
705 704
702
708 709 710
707
711 709 703 711
701
706 703
706
708
704 710
710
707 705
702
704
701
706
ITEM #
PART #
-
231-2262
DESCRIPTION
701 702
126-7135
OUTPUT PLANET CARRIER
1
231-2263
PLANET GEAR
3
703
126-0786
PLANET PIN
704
126-0785
ROLLER
705
126-0779
BEARING SPACER
3
706
126-0784
THRUST WASHER
6
707
4H-4737
ROLL PIN
3
OUTPUT PLANET CARRIER ASSEMBLY
QTY 1
3 120
708
126-0783
RETAINING RING
1
709
126-0847
DRUM SHAFT
1
710 711
126-0782 126-0781
RETAINING RING THRUST RACE
2 1
26
METRIC CONVERSION TABLE English to Metric
Metric to English LINEAR
inches (in.) feet (ft.) miles (mi.)
X 25.4 X 0.3048 X 1.6093
= millimeters (mm) = meters (m) = kilometers (km)
millimeters (mm) meters (m) kilometers (km)
X 0.3937 X 3.281 X 0.6214
= inches (in.) = feet (ft.) = miles (mi.)
AREA 2
2
2
millimeters 2 (mm 2) meters2 (m 2)
inches (sq.in.) feet2 (sq.ft.)
X 645.15 X 0.0929
= millimeters (mm ) = meters2 (m 2)
inches3 (cu.in.) quarts (qts.) gallons (gal.) inches3 (cu.in.) feet3 (cu.ft.) feet3 (cu.ft.) fluid ounce (fl.oz.)
X X X X X X X
0.01639 0.94635 3.7854 16.39 28.317 0.02832 29.57
= liters (l) = liters (l) = liters (l) = centimeters3 (cc) = liters (l) = meters3 (m 3) = millileters (ml)
ounces (oz.) pounds (lbs.) tons (2000 lbs.) tons (2000 lbs.) tons (long) (2240 lbs.)
X X X X X
28.35 0.4536 907.18 0.90718 1013.05
= grams (g) = kilograms (kg) = kilograms (kg) = metric tons (t) = kilograms (kg)
inches Hg (60oF) pounds/sq.in. (PSI) pounds/sq.in. (PSI) pounds/sq.in. (PSI) o inches H2O (60 F) bars
X X X X X X
3600 6.895 0.0703 0.069 0.2488 100
= kilopascals (kPa) = kilopascals (kPa) = kilograms/sq.cm. (kg/cm 2) = bars = kilopascals (kPa) = kilopascals (kPa)
horsepower (hp) ft.-lbs./min.
X 0.746 X 0.0226
X 0.000155 = inches2 (sq.in.) = feet 2 (sq.ft.) X 10.764
VOLUME liters (l) liters (l) liters (l) centimeters3 (cc) liters (l) meters3 (m3) milliliters (ml)
X X X X X X X
61.024 1.0567 0.2642 0.06102 0.03531 35.315 0.03381
= = = = = = =
inches3 (cu.in.) quarts (qts.) gallon (gal.) inches3 (cu.in.) feet 3 (cu.ft.) feet 3 (cu.ft.) fluid ounce (fl.oz.)
X X X X X
0.03527 2.2046 0.001102 1.1023 0.000984
= = = = =
ounces (oz.) pounds (lbs.) tons (2000 lbs.) tons (2000 lbs.) tons (long) (2240 lbs.)
X X X X X X
0.2961 0.145 14.22 14.5 4.0193 0.01
= inches Hg (60oF) = pounds/sq.in. (PSI) = pounds/sq.in. (PSI) = pounds/sq.in. (PSI) o = inches H2O (60 F) = bars
MASS grams (g) kilograms (kg) kilograms (kg) metric tons (t) kilograms (kg)
PRESSURE kilopascals (kPa) kilopascals (kPa) kilograms/sq.cm. (kg/cm2) bars kilopascals (kPa) kilopascals (kPa)
POWER = kilowatts (kW) = watts (W)
kilowatts (kW) watts (W)
X 1.34 X 44.25
= horsepower (hp) = ft.-lbs./min.
X 8.851 X 0.7376 X 7.233
= pound-inches (in.lbs.) = pound-feet (ft.-lbs.) = pound-feet (ft.-lbs.)
X 0.6214 X 3.281 X 3.281
= miles/hour (m/h) = feet/second (ft./sec.) = feet/minute (ft./min.)
TORQUE pound-inches (in.-lbs.) X 0.11298 pound-feet (ft.-lbs.) X 1.3558 pound-feet (ft.-lbs.) X .1383
= newton-meters (N-m) = newton-meters (N-m) = kilograms/meter (kg-m)
miles/hour (m/h) feet/second (ft./sec.) feet/minute (ft./min.)
= kilometers/hour (km/hr) = meter/second (m/s) = meter/minute (m/min)
newton-meters (N-m) newton-meters (N-m) kilogram/meter (kg-m)
VELOCITY X 0.11298 X 0.3048 X 0.3048
kilometers/hour (km/hr) meters/second (m/s) meters/minute (m/min)
TEMPERATURE o
o
o
Celsius = 0.556 ( F - 32)
Fahrenheit = (1.8 X oC) + 32
COMMON METRIC PREFIXES mega kilo hecto deka
(M) (k) (h) (da)
= = = =
1,000,000 or 106 1,000 or 103 100 or 102 10 or 101
deci centi milli micro
27
(d) (c) (m) (m)
= = = =
0.1 or 10-1 0.01 or 10-2 0.001 or 10-3 0.000.001 or 10-6
